MATERIAL SAFETY DATA SHEET
ORIGINAL KRUD KUTTER
Page 1 of 3
ORIGINAL KRUD KUTTER
SECTION I
MANUFACTURED BY: SUPREME CHEMICALS OF GEORGIA, INC.
ADDRESS: 1535 Oak Industrial Lane, Suite B
Cumming, GA 30041
EMERGENCY PHONE NUMBER: (800) 255-3924 CHEMTEL for EMERGENCY ONLY
PHONE NUMBER FOR INFORMATION: (800) 466-7126
DATE REVISED: June 21, 2000
NAME OF PREPARER: CLIFFORD M. CANTRELL
SECTION II HAZARDOUS INGREDIENTS/INFORMATION
INGREDIENT CAS NO. OSHA
PEL - TWA
ACIGH
TLV - TWA
OTHER
STEL
% OR
RNG
SK
2-BUTOXYETHANOL 111-76-2 25 PPM 25 PPM 50 PPM < 8 x
ETHANOL, 2-AMINO 141-43-5 2 mg/m3 2 mg/m3 5 mg/m3 < 4
POTASSIUM HYDROXIDE 1310-58-3 2 PPM 2 PPM 5 PPM < 2
NOTE: AN 'x' UNDER 'SKIN' INDICATES THAT OSHA REQUIRES SKIN PROTECTION TO PREVENT OR REDUCE EXPOSURE
TO THIS INGREDIENT. ETHANOL, 2-AMINO and 2-BUTOXYETHANOL ARE SARA TITLE III, SECTION 313 SUBSTANCES
WHICH MAY BE SUBJECT TO REPORTING BY MANUFACTURING SECTOR USERS.
EPA HAZARD CATEGORIES
ACUTE HEALTH - CHRONIC HEALTH
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 212oF Specific Gravity (H2O=1) 1.01 - 1.02
Vapor Pressure (mm Hg) 17 Melting Point < 30OF
Vapor Density (Air=1) 3.2 Evaporation Rate (Water=1) < 1
Solubility in Water: Complete
Appearance and odor: Clear liquid with mild odor.
SECTION IV- FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): None Flammable Limits: LEL: N/A UEL: N/A
Extinguishing Media: Carbon dioxide, dry chemical, alcohol foam, water fog
Special Fire Fighting Procedures: FIREFIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING WHEN FIGHTING FIRES INVOLVING THIS PRODUCT.
Unusual Fire and Explosion Hazards: None known.
SECTION V- REACTIVITY DATA
Stability: Stable
Incompatibility (Materials to Avoid): Do not mix with alkalies or oxidizing agents.
Hazardous Decomposition or Byproducts: Heat and carbon dioxide.
Hazardous Polymerization: Will Not Occur
HAZARD RATINGS
NFPA HMIS DATA
HEALTH 1 0= MINIMAL
1= SLIGHT
FIRE 0 2=MODERATE
3=HIGH
REACTIVITY 1 4=EXTREME
HAZARD RATINGS
NFPA HMIS DATA
HEALTH 1 0= MINIMAL
1= SLIGHT
FIRE 0 2=MODERATE
3=HIGH
REACTIVITY 0 4=EXTREME
MATERIAL SAFETY DATA SHEET
ORIGINAL KRUD KUTTER
Page 2 of 3
SECTION VI- HEALTH HAZARD DATA
Route(s) of Entry: Inhalation? Yes Skin? Yes Ingestion? Yes Eyes? Yes
Health Hazards (Acute and Chronic): None known.
Carcinogenicity:
NTP? Ingredients not listed.
IARC Monographs? Ingredients not listed.
OSHA Regulated? Ingredients not listed.
Signs and Symptoms of Exposure:
INHALATION: Irritation of respiratory system with possible difficulty in breathing.
INGESTION: Small amounts may cause gastric distress, diarrhea and vomiting.
SKIN CONTACT: Possible irritation. Concentrated material may be absorbed through skin.
EYE CONTACT: Irritation and burning sensation with possible corneal damage.
Medical Conditions Generally Aggravated by Exposure: Unknown
Emergency and First Aid Procedures:
INGESTION: Give 3-4 glasses of water. Do not administer fluids to an unconscious person. Do not Induce vomiting.
GET MEDICAL ATTENTION IMMEDIATELY.
INHALATION: Remove victim to fresh air. If breathing does not return to normal, GET MEDICAL ATTENTION.
EYE CONTACT: Immediately flush eyes in clear running water for at least 15 minutes lifting upper and lower lids
periodically.If irritation results and persists, GET MEDICAL ATTENTION.
SKIN CONTACT: Flush skin with clear running water for at least 15 minutes. If irritation results and persists, GET
MEDICAL ATTENTION.
SECTION VII- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to Be Taken in Case Material is Released or Spilled:
SMALL SPILLS: Flush to sanitary sewer.
LARGE SPILLS: Dike to avoid spreading. Transfer to sealable containers for disposal at an approved hazardous waste site. Rinse
spill area with water. Report any releases to ground or surface waters.
Waste Disposal Method: Consign wastes to Federal, State, and locally approved hazardous waste disposal facility for
neutralization.
Precautions to Be Taken in Handling and Storing: Do not freeze. Follow all label instructions. Keep container closed when not in
use.
Other Precautions: KEEP THIS AND ALL CHEMICALS OUT OF REACH OF CHILDREN.
Container Disposal: Triple rinse and puncture containers before disposing into sanitary waste for landfill.
SECTION VIII- Control Measures
Respiratory Protection (Specify Type): For use in enclosed areas, when spraying or when concentration in air exceeds limits (see
SECTION II), use NIOSH/MSMS approved CCR-AV or better respirator.
Ventilation: GENERAL EXHAUST AS REQUIRED TO MAINTAIN CONCENTRATION BELOW PEL.
Protective Gloves: Rubber or neoprene.
Eye Protection: Chemical goggles recommended when using any chemical.
Other Protective Clothing or Equipment: As required to reduce or prevent skin contact. Wash contaminated clothing before reuse.
Work/Hygienic Practices: Wash product from clothes and skin. Use good housekeeping practices.
SECTION IX - Additional Information
ENVIRONMENTAL
BIODEGRADABILITY: BIODEGRADABLE.
WASTE DISPOSAL METHODS: DISPOSE OF IN AN AUTHORIZED WASTE FACILITY IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
ADDITIONAL INFORMATION
EMPTY CONTAINER HANDLING: WARNING! EMPTIED CONTAINER RETAINS PRODUCT RESIDUE. OBSERVE ALL PRECAUTIONS
EVEN AFTER CONTAINER IS EMPTIED. KEEP EMPTY CONTAINER CLOSED TIGHTLY.
MATERIAL SAFETY DATA SHEET
ORIGINAL KRUD KUTTER
Page 3 of 3
SARA TITLE III REPORTING REQUIREMENTS
SECTION 302- EXTREMELY HAZARDOUS SUBSTANCES REPORTING NOT REQUIRED
SECTION 304- HAZARDOUS RELEASES REPORTING NOT REQUIRED
SECTION 311- COMMUNITY RIGHT TO KNOW (R-T-K) REPORTING REQUIRED FOR INVENTORY ABOVE TPQ.
SECTION 312- R-T-K INVENTORY DATA REPORTING REQUIRED FOR INVENTORY ABOVE TPQ.
SECTION 313- EMISSIONS AND RELEASE REPORTING MAY BE REQUIRED FOR
MANUFACTURING SECTOR USERS
CERCLA SAME AS SECTION 304
REFERENCES
TOXIC SUBSTANCE CONTROL ACT LIST (TSCA) - INGREDIENTS LISTED.
PERMISSIBLE EXPOSURE REFERENCES:
REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES
TITLE 29 CODE OF FEDERAL REGULATIONS
NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) MONOGRAPHS
REGULATORY STANDARDS:
DOT TITLE 49 CODE OF FEDERAL REGULATIONS 172.101
SARA TITLE III
NUCLEAR REGULATORY AGENCY
THIS DOCUMENT COMPLIES WITH OSHA FORM 174 AS REQUIRED UNDER 29 CFR 1910.1200.
THE INFORMATION CONTAINED HEREIN is believed to be accurate but is not warranted to be so. Users are advised to confirm in
advance of need that information is current, applicable and suited to the circumstances of use. Vendor assumes no responsibility
for injury to vendee or third persons proximately caused by the material if reasonable safety procedures are not adhered to as
stipulated in the data sheet. Furthermore, vendor assumes no responsibility for injury caused by abnormal use of this material even
if reasonable safety procedures are followed.