Formula: B902 1
Material Safety Data Sheet HMIS?
HEALTH
FLAMMABILITY
2
2
REACTIVITY
PERSONAL PROTECTION
0
B
Identity: Metal Polishing SCRUBS®
Formula: B902
Part numbers: 90201, 90218, 90236
Note: Blank spaces are not permitted. If any item is not applicable, or no
information is available, the space must be marked to indicate that.
SECTION 1: Company Identification
Manufacturer's Name
ITW Dymon
Emergency Telephone Number
1-800-535-5053
Address (Number, Street, City, State, and ZIP Code)
805 East Old 56 Highway
International Emergency Telephone Number
1-352-323-3500
Olathe, Kansas 66061
Telephone Number for Information
1-913-397-9889
Signature of Preparer (Optional)
Regulatory Dept.
SECTION 2: Ingredients/Identity Information
Components (Chemical Identity, Other Limits
Common Name(s)) CAS No. OSHA PEL ACGIH-TLV Recommended % (Opt.)
C10-13 Isoparaffin 68551-17-7 None None 400 ppm (Manu.) 15 – 40%
Alumina 1344-28-1 5 mg/m3 10 mg/m3 10 – 30%
Ammonia 1336-21-6 50 ppm 25 ppm STEL35 ppm 1 – 5%
Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or
Texas is described above if known present in regulated concentrations.
SECTION 3: Hazards Identification
Route(s) of Entry Eyes?
Yes
Inhalation?
Yes
Skin?
Yes
Ingestion?
Yes
Acute Health Hazards - Warning. Contains petroleum distillates. May be harmful or fatal if swallowed. Causes eye irritation or burns.
Combustible material. May cause skin irritation. May be harmful if inhaled.
Chronic Health Hazards - None known
Carcinogenicity:
Carcinogenicity OSHA:
No
NTP:
No
IARC:
No
Signs and Symptoms of Exposure - Redness, tearing or burning in eyes. Redness, drying or irritation of skin. Irritation of the throat or stomach,
nausea, vomiting, and diarrhea if swallowed. Excessive inhalation of vapors may cause irritation of the nose, throat and respiratory tract.
Medical Conditions Generally Aggravated by Exposure - Pre-existing skin conditions such as dermatitis may be adversely affected by this and
other oil and grease effective cleaners. Pre-existing respiratory and eye conditions may be adversely affected.
SECTION 4: Emergency and First Aid Procedures:
Eyes - Flush with plenty of water for at least 15 minutes lifting eyelids to insure complete removal. Get medical attention immediately.
Ingestion - Not a likely exposure route. If a large quantity of liquid is swallowed, do NOT induce vomiting, call a physician or poison control
center immediately.
Inhalation - If overexposed move into fresh air. If symptoms develop seek medical attention.
Skin - Wash thoroughly with soap and water. Get medical attention if irritation develops and persists.
SECTION 5: Fire Fighting Measures
Flash Point (Method Used)
Liquid phase 153o F (PMCC)
Flammable Limits
No Data
LEL
No Data
UEL
No Data
Extinguishing Media - Use carbon dioxide, dry chemical, foam, or fog. Treat as an oil fire.
Special Fire Fighting Procedures - Keep containers cool and vapors down with water spray. Prevent runoff from entering sewers and public
waterways. Wear SCBA in chemical fires.
Formula: B902 2
Hazardous Products of Combustion-Carbon dioxide, carbon monoxide, hydrogen, ammonia, amines, nitrogen and oxides, oxides of sulfur,
smoke, and soot.
Unusual Fire and Explosion Hazards - Liquid is combustible. May cause polypropylene cloth to burn at higher temperature.
SECTION 6: Accidental Release Measures
Small Spill - Wipe up small releases with a dry absorbent cloth or other absorbent material.
Large Spill – Absorb liquid with vermiculite, absorbent cloth, or other absorbent material. Prevent material from entering sewers or drains.
Ventilate area and block traffic. Transfer contaminated material into suitable container for proper disposal.
SECTION 7: Handling and Storage
Handling - Do not swallow. Wash thoroughly after handling. Do not use around ignition sources such as heat, sparks, open flame, static
electricity, welding arcs, etc. Do not get in eyes. Avoid inhaling vapors. Avoid contact with skin and clothing. Launder contaminated clothing
before reuse. Follow label directions carefully.
Storage – Store in a cool well ventilated area. Keep away from heat sources. Keep out of reach of children. Keep container tightly sealed when
not in use. Do not smoke while using. Do not contaminate water, food, or feed by use or storage.
SECTION 8: Exposure Controls / Personal Protection
Eye Protection – Yes, approved safety glasses (ANSI Z81) Do not allow towel to directly contact eyes.
Skin Protection – Only for prolonged use.
Respiratory Protections – Not usually necessary. Use with adequate ventilation. Use NIOSH/MSHA approved respirator if PELs or TLVs are
exceeded.
Engineering Controls – Ventilation not usually necessary but should be provided in the event of overexposure.
SECTION 9: Physical and Chemical Properties
Appearance and Odor: Opaque cream colored liquid with an ammonia-like odor saturated onto towels.
PH 9.5 + 0.5
Specific Gravity (70oF) 1.104
Boiling Point: 212o F
Melting Point: No Data
Evaporation Rate (Butyl Acetate = 1) No Data
Vapor Pressure (mm-Hg @ 70oF) No Data
Vapor Density (AIR = 1) >1
Solubility in Water Dispersible
Volatile Organic Compounds (VOCs) 331.4 grams per liter or 30% by weight VOCs.
SECTION 10: Stability and Reactivity
Hazardous Polymerization – This product will not undergo hazardous polymerization.
Hazardous Decomposition or Byproducts – Carbon dioxide, carbon monoxide, hydrogen, ammonia, amines, nitrogen and oxides, oxides of
sulfur, smoke, and soot.
Chemical Stability - Stable
Incompatibility (Materials to Avoid) - Strong oxidizers and acids, halogens, dimethyl sulfate, bleaching agents, fluorine, iodine and amphoteric
metals.
SECTION 11: Toxicological Information
No Data
SECTION 12: Ecological Information
No Data
Formula: B902 3
SECTION 13: Disposal Consideration
Disposal Method - Dispose of in accordance with all applicable local, state, and federal regulations.
RCRA Waste Information – If this product becomes a waste, it would not be a hazardous waste as defined by RCRA (40 CFR 261). However the
waste should be properly characterized to evaluate whether its composition has been modified prior to disposal.
SECTION 14: Transport Information
DOT Information – 49 CFR 172.101
Proper Shipping Description: Not Regulated
Hazard Class: None
Identification Number: None
Packing Group: None
Water Transportation:
Proper Shipping Description: Not Regulated
Hazard Class: None
Identification Number: None
Packing Group: None
Air Transportation:
Proper Shipping Description: Not Regulated
Hazard Class: None
Identification Number: None
Packing Group: None
Marine Pollutants: None
SECTION 15: Regulatory Information
US Federal Regulations:
TSCA (Toxic Substances Control Act) Status
All ingredients are on the TSCA inventory or are not required to be listed on the TSCA inventory.
CERCLA RQ – 40 CFR 302.4 (a)
None Listed
SARA 313 Components – 40 CFR 372.65
None
State and Local Regulations:
California Proposition 65
None
Section 16: Additional Information
Date Prepared
Rev. 3 – 09/06/06
Rev. 2 – 06/26/06
Rev. 1 – 09/23/05
Formula: B902 4
WARNING! The use of this product is beyond the control of the manufacturer; therefore, no guarantee, expressed or implied, is made as to the effects of such or
the results to be obtained if not used in accordance with directions or established safe practice. The user must assume all responsibility, including injury or damage,
resulting from its misuse as such, or in combination with other materials. The manufacturer warrants only that this product meets the manufacturer's specifications
for such product. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, AS TO DESCRIPTION, QUALITY,
MERCHANTABILITY. FITNESS FOR ANY PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT. THE
MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF THIS PRODUCT. The sole and exclusive remedy against the
manufacturer for breach of warranty shall be reimbursement of the purchase price of the product in the event that a defective condition of the product shall be found
to exist. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR
PROPERTY OR ANY OTHER INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.