MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER'S INFORMATION
NFPA Rating: Health-1; Flammability-1; Reactivity-0; Special- - HMIS Rating: Health-1; Flammability-1; Reactivity-0; Personal Protection-A
Manufactured for: NEXGEN/Chemstar Line
13230 Raymer St.
North Hollywood, Ca. 91605
DOT Hazard Classification: Not regulated
Identity (trade name as used on label):
QUICK ALUMINUM (ZQA-9145)
Date Prepared: 03/05/03 Prepared By: DJP Revision 1.1
Information Calls: (818) 982-5242
EMERGENCY RESPONSE NUMBER: 1(800)451-8346
NOTICE: JUDGMENT BASED ON INDIRECT TEST DATA
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
CAS Number SARA
III LIST
OSHA PEL
(ppm)
ACGIH
TLV (ppm)
%
Glycidyl ethers of bisphenol A resins 25068-38-6 No N/E N/E 10 – 30
Tri (dimethylaminomethyl) phenol 90-72-2 No N/E N/E 1 - 5
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: N/A Specific Gravity: N/A
Vapor Pressure: PSIG @ 70°F (Aerosols): N/A Vapor Pressure (Non-Aerosols)(mm Hg and Temperature): N/A
Vapor Density: Non volatile Evaporation Rate: N/A
Solubility in Water: Insoluble
Appearance and Odor: Grey colored putty with no distinguishable odor.
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME PROJECTION TEST
(aerosols) N/A
Auto Ignition Temperature
N/A
Flammability Limits in Air by % in Volume:
% LEL: N/A % UEL: N/A
FLASH POINT (non-aerosols): None (TCC)
EXTINGUISHER MEDIA: Appropriate to fire fuel source.
SPECIAL FIRE FIGHTING PROCEDURES: Wear SCBA.
Unusual Fire & Explosion Hazards: Carbon monoxide, aldehydes, acids, oxides of sulfur and nitrogen may be formed.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY [ X ] STABLE [ ] UNSTABLE HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR
Incompatibility (Mat. to avoid): None. Conditions to Avoid: None.
Hazardous Decomposition Products: Carbon monoxide, aldehydes, acids, oxides of sulfur and nitrogen.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ ] INGESTION [ X ] SKIN ABSORPTION [ ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS: None known.
Inhalation: None.
Eye Contact: Possible irritant and sensitizer. Skin Contact: Possible irritant and sensitizer.
Ingestion: Irritation of intestinal tract.
CHRONIC EFFECTS: None known.
Medical Conditions Generally Aggravated by Exposure: Pre-existing contact site disorders.
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for 15 minutes while holding the upper and lower lids open. If irritation persists, get medical attention.
Skin Contact: Wash affected area well with soap and water. If irritation persists, get medical attention.
Inhalation: Since this product is not expected to be an immediate inhalation problem, no first aid procedures are required.
Ingestion: INDUCE VOMITING. Get immediate medical attention.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): Not normally required when used in accordance with label directions.
Protective Gloves: Polyethylene gloves for prolonged use. Eye Protection: Safety glasses or goggles.
Ventilation Requirements: Local exhaust.
Other Protective Clothing & Equipment: None.
Hygienic Work Practices: Wash with soap and water immediately after use. If sanding cured putty or substrates, wear eye protection and dust mask.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released: Product is in putty form, and hence will not spill.
Waste Disposal Methods: Incinerate in furnace or bury in landfill according to applicable local, state and federal regulations.
Precautions To Be Taken In Handling & Storage: Store in original shipping containers . Keep closed when not in use. Shelf life 1 year.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Read & follow label directions.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any
kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only