Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: COUNTERMANS CHOICE MED STR THREADLOCKER BLUE 1ML
Item No: 09178
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient Weight Percent ACGIH TLV: OSHA PEL:
POLYGLYCOL DIMETHACRYLATE
25852-47-5
60-70 Not Listed Not Listed
TETRAETHYLENE GLYCOL
HEXOATE
18268-70-7
20-30 Not Listed Not Listed
SILICA, AMORPHOUS TREATED
68909-20-6
1-10 10 mg/m3 inhal; 3 mg/m3 respir 20 mppcf
ETHYLENE GLYCOL
107-21-1
1-10 100 mg/m3 ceiling (aerosol only) 50 ppm ceiling; 125 mg/m3 ceiling
DIMETHYLBENZYL
HYDROPEROXIDE
80-15-9
<3 Not Listed Not Listed
SACCHARIN
81-07-2
1-10 10mg/m3 nuisance dust Not Listed
TITANIUM DIOXIDE
13463-67-7
0.1-1.0 10 mg/m3 TWA ACGIH 15 mg/m3 TWA (total dust)
3. HAZARDS IDENTIFICATION
Toxicity: Dermal toxicity of the finished product is greater than 5000 mg/kg. Oral toxicity of the finished product is
greater than 10,000 mg/kg (rat). May cause eye and skin irritation.
Primary Routes of Entry: Eye and skin contact, ingestion, inhalation
Signs and Symptoms of Exposure: Repeated skin contact may cause allergic skin reactions. Overexposure may cause eye and skin redness.
Ingredient Weight
Percent
NTP ACGIH Carcinogens IARC
ETHYLENE GLYCOL
107-21-1
1-10 male mice-no
evidence; female
mice-no evidence
A4 - not classifiable
as a human
carcinogen (aerosol)
SACCHARIN
81-07-2
1-10 Delisted April 2000 Group 3: Vol 73, Page 517:
1999
TITANIUM DIOXIDE
13463-67-7
0.1-1.0 male rat-negative,
female rat-negative,
male mice-negative,
female mice-negative
A4 Group 2B; Vol 93,2006; Vol
47,1989
Medical Conditions Recognized as
Being Aggravated by Exposure:
Preexisting skin disorders.
4
. FIRST AID MEASURES
Ingestion: If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Inhalation: Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Skin Contact: Wash off with soap and water. If skin irritation persists, call a physician.
Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Flash Point (°F/C): More than 200 degrees F. Method: Tag Closed Cup
Recommended Extinguishing Media: Carbon dioxide, Water, dry chemical
1 of 3
COUNTERMANS CHOICE MED STR
THREADLOCKER BLUE 1ML
Product Name: Item No: 09178
5. FIRE FIGHTING MEASURES
Special Fire-Fighting Procedures: Firefighters should wear self-contained breathing apparatus.
Hazardous Products of Combustion: Irritating vapors, Oxides of carbon
Unusual Fire/Explosion Hazards: None.
Lower Explosive Limit: Not determined
Upper Explosive Limit: Not determined
6
. ACCIDENTAL RELEASE MEASURES
Spill Procedures: Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
disposal.
7. HANDLING AND STORAGE
Storage: Store below 100 degrees F.
Handling: Avoid prolonged skin contact. Keep away from eyes.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eyes: Safety glasses
Skin: Rubber or plastic gloves.
Ventilation: General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
Respiratory Protection: An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Blue liquid
Odor: MILD
Boiling Point: More than 300 degrees F.
pH: Does not apply
Solubility in Water: Insoluble
Specific Gravity: 1.09
VOC Content(Wt.%): <3% by weight
Vapor Pressure: Less than 5 mm Hg
Vapor Density (Air=1): 1.01
Evaporation Rate: Low
10. STABILITY AND REACTIVITY
Chemical Stability: Stable at normal conditions
Hazardous Polymerization: MAY OCCUR.
Incompatabilities: Strong oxidizers, free radical initiators, inert gases.
Conditions to Avoid: Heat
Hazardous Products of Combustion: Irritating vapors, Oxides of carbon
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
US EPA Waste Number: NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: Unrestricted
Hazard Class: None
2 of 3
COUNTERMANS CHOICE MED STR
THREADLOCKER BLUE 1ML
Product Name: Item No: 09178
UN/ID Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Not regulated
Class or Division: None
UN/NA Number: None
IMDG
Proper Shipping: Unrestricted
Hazard Class: None
UN Number: None
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
1
6. OTHER INFORMATION
Estimated NFPA Rating: HEALTH 1, FLAMMABILITY 1, INSTABILITY 1
Estimated HMIS Classification: HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
3 of 3
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106
Prepared By:
Revision
Number:
2
Denise Boyd, Health and Safety Manager Revision Date: December/19/2006