Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: COUNTERMANS CHOICE HI STR THREADLOCKER RED 1ML
Item No: 09179
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient Weight Percent ACGIH TLV: OSHA PEL:
POLYGLYCOL DIMETHACRYLATE
25852-47-5
60-75 Not Listed Not Listed
POLYESTER RESIN
39382-25-7
20-30 Not Listed Not Listed
SACCHARIN
81-07-2
<5 10mg/m3 nuisance dust Not Listed
N,N-DIALKYTOLUIDINE
613-48-9
<3 Not Listed Not Listed
DIMETHYLBENZYL
HYDROPEROXIDE
80-15-9
<3 Not Listed Not Listed
METHANOL
67-56-1
0.1-1.0 200 ppm TWA 200 ppm TWA; 260 mg/m3 TWA
3. HAZARDS IDENTIFICATION
Toxicity: May cause eye, skin and respiratory irritation. Methanol may cause blindness or death if swallowed.
Primary Routes of Entry: Eye and skin contact, ingestion, inhalation
Signs and Symptoms of Exposure: Repeated skin contact may cause allergic skin reactions.
Ingredient Weight
Percent
NTP ACGIH Carcinogens IARC
SACCHARIN
81-07-2
<5 Delisted April 2000 Group 3: Vol 73, Page 517:
1999
Medical Conditions Recognized as
Being Aggravated by Exposure:
Preexisting eye, skin and respiratory disorders may be aggravated by overexposure to this product.
4
. FIRST AID MEASURES
Ingestion: If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Inhalation: Move to fresh air in case of accidental inhalation of vapours.
Skin Contact: Wash off with soap and water. If skin irritation persists, call a physician.
Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Flash Point (°F/C): >200° F TOC
Recommended Extinguishing Media: Carbon Dioxide, Dry Chemicals, Foam.
Special Fire-Fighting Procedures: Firefighters should wear self-contained breathing apparatus.
Hazardous Products of Combustion: Irritating vapors
Unusual Fire/Explosion Hazards: None.
Lower Explosive Limit: Not determined
Upper Explosive Limit: Not determined
1 of 3
COUNTERMANS CHOICE HI STR
THREADLOCKER RED 1ML
Product Name: Item No: 09179
6. ACCIDENTAL RELEASE MEASURES
Spill Procedures: Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
disposal.
7. HANDLING AND STORAGE
Storage: Store below 100 degrees F.
Handling: Avoid prolonged skin contact. Keep away from eyes.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eyes: Safety glasses
Skin: Rubber or plastic gloves.
Ventilation: General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
Respiratory Protection: An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Red liquid
Odor: MILD
Boiling Point: >400°F @ 760 mm
pH: Does not apply
Solubility in Water: Insoluble
Specific Gravity: 1.1
VOC Content(Wt.%): 2.5% by weight; 28 g/l
Vapor Pressure: <5 mm Hg
Vapor Density (Air=1): 1.01
Evaporation Rate: Low
10. STABILITY AND REACTIVITY
Chemical Stability: Stable at normal conditions
Hazardous Polymerization: MAY OCCUR.
Incompatabilities: Reducing agents
Conditions to Avoid: Heat
Hazardous Products of Combustion: Irritating vapors
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
US EPA Waste Number: NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: Unrestricted
Hazard Class: None
UN/ID Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Not regulated
Class or Division: None
UN/NA Number: None
IMDG
2 of 3
COUNTERMANS CHOICE HI STR
THREADLOCKER RED 1ML
Product Name: Item No: 09179
Proper Shipping: Unrestricted
Hazard Class: None
UN Number: None
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
1
6. OTHER INFORMATION
Estimated NFPA Rating: HEALTH 1, FLAMMABILITY 1, INSTABILITY 1
Estimated HMIS Classification: HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
3 of 3
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106
Prepared By:
Revision
Number:
2
Denise Boyd, Health and Safety Manager Revision Date: January/11/2007